+44 (0)24 7671 8970
More publications     •     Advertise with us     •     Contact us
News Article

Mercury-free UVC Disinfection

News

Asahi Kasei demonstrates Crystal IS UVC LED technology

In a bacterial performance test, Japanese multinational Asahi Kasei and subsidiary Crystal IS have shown that an experimental Klaran WR water treatment reactor demonstrated over 75 percent higher performance than a traditional low pressure mercury lamp system using an equivalent power consumption level.

Klaran WR is an inline Point of Use (PoU) water treatment reactor (Fig. 1, left) which combines Crystal IS' UVC LEDs based on aluminum nitride (AlN) substrates (Fig. 1, right), with Asahi Kasei's R&D capability in the design and application of optics and fluid-dynamics.

While conventional UV water treatment systems have used mercury lamps as a light source, nations around the world adopted stricter regulations after the Minamata Convention on Mercury became effective in 2017, due to the hazards that mercury poses to health and the environment. UVC LEDs have been developed as a mercury-free light source featuring small size, light weight, and flexibility in design. A key milestone speeding the transition to this modern light source is demonstrating that the disinfection performance, power efficiency and value of the new LED technology can fully meet or exceed the incumbent mercury lamp.

While it is widely understood and accepted that UVC LED's instant on-off capability offers a significant advantage and better alignment with actual consumer use than an “always on” mercury lamp system, a question remained whether an equivalent powered LED system could demonstrate equivalent disinfection performance as a low-pressure mercury lamp system. The experimental Klaran WR reactor was developed to demonstrate that UVC LEDs can achieve just this.

A standard Klaran WR was enhanced and modified to operate with the same power consumption level (6 W) as a comparable mercury lamp system. Both systems were tested using water at a flow rate of 8 litres per minute (2.1 gallons per minute), with a UV transmittance of 97 percent at 265 nm and dosed with the addition of approximately 106 CFU/mL of E. coli, a common gram-negative, facultative anaerobic, rod-shaped bacteria, for testing.

As there is no established testing method for this type of comparison, Asahi Kasei devised the testing method and contracted an independent laboratory to perform the evaluation. Water quality samples recorded after 2 minutes steady operation with both systems were compared (see graph above), demonstrating how the Klaran WR had over 2 LRV (logarithmic reduction value) better performance than the mercury lamp system. Put another way, the Klaran WR system reduced E. Coli in the water to 1/100 of the level of the water disinfected by the mercury lamp system.

It is Asahi Kasei's belief that by replacing mercury lamps in water treatment systems with Crystal IS UVC LEDs, it will contribute to the realization of a mercury-free world and meet the global need for energy efficiency and safer water. In addition to water treatment system, Crystal IS will apply the various advantages of UVC LEDs to expand the application of UVC LEDs in surface and air disinfection

CS International to return to Brussels – bigger and better than ever!


The leading global compound semiconductor conference and exhibition will once again bring together key players from across the value chain for two-days of strategic technical sessions, dynamic talks and unrivalled networking opportunities.


Join us face-to-face on 18-19 April 2023

  • View the agenda.
  • 3 for the price of 1. Register your place and gain complementary access to TWO FURTHER industry leading conferences: PIC International and Power Electronics International.
  • Email info@csinternational.net  or call +44 (0)24 7671 8970 for more details.

Register


×
Search the news archive

To close this popup you can press escape or click the close icon.
×
Logo
×
Register - Step 1

You may choose to subscribe to the Compound Semiconductor Magazine, the Compound Semiconductor Newsletter, or both. You may also request additional information if required, before submitting your application.


Please subscribe me to:

 

You chose the industry type of "Other"

Please enter the industry that you work in:
Please enter the industry that you work in: